Gearbox Drain plug seal

Got a technical query? Found another 0.02bhp? Ask/tell the world.

Moderators: Gromit, Paul, slparry

Post Reply
User avatar
julian
Member
Posts: 1210
Joined: Sun Feb 22, 2004 7:25 pm
Location: W. London

Postby julian » Mon Apr 30, 2007 3:02 pm

Keep up folks, the smart London set use this Classic Mercedes Tool
BMW R1100S (Black)
Suzuki TL1000S (Red)
Top
User avatar
bigblackfalco
Posts: 1922
Joined: Wed Feb 18, 2004 10:05 am
Location: Darkest Aberdeenshire

Postby bigblackfalco » Mon Apr 30, 2007 7:05 pm

julian wrote:Keep up folks, the smart London set use this Classic Mercedes Tool
Only you could come up with that one! Where on earth did you find that?! :wink:
Honda VFR750 FV 1997 Red and dirty, 130K miles.

Honda VFR800 Xf Crossrunner 2016 White and dirty, 120K miles.
Top
User avatar
bigblackfalco
Posts: 1922
Joined: Wed Feb 18, 2004 10:05 am
Location: Darkest Aberdeenshire

Postby bigblackfalco » Mon Apr 30, 2007 7:08 pm

snavetrauts wrote:BigBlackfalco, I will give that a try but I will buy an allan key or preferably a socket driver if there is one.

BTW... When I changed the engine oil... the colour was a ruddy brown... not the normal black tinge you normally get from well used oil.

I only changed it because Vines had said they had done a full 6000 mile service when I bought it.. but the air filter was knackered... Whether this would be changed or not, I assumed they would change this as it was so bad..But NO!... So I thought I would do a complete service.

I assume they had changed the oil... so this has done about a 1000 miles since new...BUT ruddy brown... no frothing felt very viscous still... but the colour...ANY IDEAS folks??? :?: :?:
Brown oil is a sign of water/ rust. Also a sign of cheap nasty oil!
Happens lots on 'short run' vehicles where the engine doesn't reach optimum running temp.
Honda VFR750 FV 1997 Red and dirty, 130K miles.

Honda VFR800 Xf Crossrunner 2016 White and dirty, 120K miles.
Top
User avatar
chobbler
Posts: 46
Joined: Fri Apr 14, 2006 1:17 pm

Postby chobbler » Mon Apr 30, 2007 7:17 pm

Redline shockproof oil goes browny red with age, no water involved. Don't ask how I know. :oops:
Brockworth Gloucs
Top
darkness
Posts: 172
Joined: Mon Nov 27, 2006 12:24 am
Location: SOUTH LONDON

Postby darkness » Tue May 01, 2007 10:27 pm

Hi all

Made a few phone calls with regard to the fitting of a seal, according to a couple of dealers, no washer is fitted as the plug is tapered, hence the need to tighten the plug to 55nm.

The parts cats also does not show a seal.

So now I can refill the gearbox for the weekend and see how mobil gear oil performs.

Darkness
Top
User avatar
oyster
Posts: 1236
Joined: Fri Jul 02, 2004 1:03 pm
Location: retirementland kent

Postby oyster » Wed May 02, 2007 5:31 pm

Joe's Mobil gear oil is proof of rider's sensitivity! If you dont notice the improvement, I'd recommend cutting down on the neck oil. :D
Oyster. 1999 R1100S. Almost original.
Top
User avatar
julian
Member
Posts: 1210
Joined: Sun Feb 22, 2004 7:25 pm
Location: W. London

Postby julian » Thu May 03, 2007 11:21 am

bigblackfalco wrote:
julian wrote:Keep up folks, the smart London set use this Classic Mercedes Tool
Only you could come up with that one! Where on earth did you find that?! :wink:


I got it on ebay Califiornia USA after reading about them on on the Pelican board.
BMW R1100S (Black)

Suzuki TL1000S (Red)
Top
Adski
Posts: 101
Joined: Thu Jan 12, 2006 10:56 am

Postby Adski » Tue May 08, 2007 5:05 pm

On the topic of the 14mm hex issue...I brought one from Coulsdon Auto's earlier today for under £2.
I guess car's have large hex drain plugs too as that's what it was labelled as!
I got the last one in stock though. :P
Mr Sensible.
Top
User avatar
Dog Tyred
Member
Posts: 2696
Joined: Wed Jan 18, 2006 12:27 pm
Location: Tamuff

Postby Dog Tyred » Tue May 08, 2007 10:44 pm

Adski wrote:On the topic of the 14mm hex issue...I brought one from Coulsdon Auto's earlier today for under £2.
I guess car's have large hex drain plugs too as that's what it was labelled as!
I got the last one in stock though. :P


Aye, but does it fit between plug and the exhaust collar???
Ride like your life depended on it.

2002 BCR
Top
Adski
Posts: 101
Joined: Thu Jan 12, 2006 10:56 am

Postby Adski » Wed May 09, 2007 5:04 pm

Nu2beemers wrote:Aye, but does it fit between plug and the exhaust collar???


Just...but there's no way I can get a socket on there. However the hex bit is long enough to get a spanner on it.
Mr Sensible.
Top
Post Reply

Return to “Boxertech”

Who is online

Users browsing this forum: No registered users and 17 guests